Determining The Role of Ion Exchange in Permeability Alteration During Asp Injection: A Laboratory-Scale Study Using Cmg Reactive Transport Modeling

Dike Fitriansyah Putra; Mohd Zaidi Jaafar; Tengku Amran Tengku Mohd; Novia Rita; Agus Dahlia; Ichsan Al Sabah Lukman; M. Haidar T. Putra

Authors

Dike Fitriansyah Putra Universitas Islam Riau
Prof. Mohd Jaafar Universiti Teknologi Malaysia
Dr. Tengku Amran universiti teknologi Mara (UiTM)
Ms. Noviarita Universitas Islam Riau
Ms. Agus Dahlia Universitas Islam Riau
Mr. Ichsan Center of Energy Studies UIR
M. Haidar T. Putra Earth Science Department, University of Calgary, Calgary, AB, Canada

Keywords:

Electro-kinetic EOR, ion exchange, permeability evolution, reactive transport simulation, ASP injection

Abstract

Electrokinetic-based Enhanced Oil Recovery (EK-EOR) presents a novel method that applies electric fields to mobilize trapped hydrocarbons in formations with low permeability. This work investigates the impact of ion exchange and mineralogical reactions on permeability behavior during Alkali-Surfactant-Polymer (ASP) flooding, integrating laboratory-scale sand-pack experiments with reactive transport simulation in CMG-GEM. During ASP injection, a marked rise in differential pressure indicated abrupt changes in permeability caused by polymer accumulation, mineral dissolution, and early-stage ion exchange. Two numerical scenarios were assessed: one involving only aqueous-phase chemistry, and another incorporating fluid reactions and solid-surface ion exchange. The latter case required minimal calibration to match experimental data, while the former demanded unrealistic permeability upscaling. The results underscore ion exchange as a vital mechanism influencing fluid transport in EK-EOR. Although wettability alteration is often associated with ASP processes, this study suggests that under short exposure periods, changes in permeability dominate recovery performance. The findings improve reservoir modeling by promoting geochemical integration into simulation workflows.

Author Biography

Dike Fitriansyah Putra, Universitas Islam Riau

Dosen Tetap Prodi Teknik Perminyakan Universitas Islam Riau

References

Alghamdi, A., Ayirala, S., Alotaibi, M., & Alyousef, A. (2019). SmartWater Synergy with Surfactant Chemicals : An Electro-Kinetic Study. The Abu Dhabi International Petroleum Exhibition & Conference, November 1–12.

Alizadeh, A., Huang, Y., Liu, F., Daiguji, H., & Wang, M. (2023). A streaming-potential-based microfluidic measurement of surface charge at an immiscible liquid-liquid interface. International Journal of Mechanical Sciences, 247 (January), 108200. https://doi.org/10.1016/j.ijmecsci.2023.108200

Alshawabkeh, A. N. (2009). Electro-kinetic soil remediation: challenges and opportunities. Separation Science and Technology, 44(10), 2171–2187.

Bartels, J., Kühn, M., Schneider, W., Clauser, C., Pape, H., Meyn, V., & Lajcsak, I. (2002). Core flooding laboratory experiment validates numerical simulation of induced permeability change in reservoir sandstone. Geophysical Research Letters, 29(9), 34-1-34–4. https://doi.org/10.1029/2002gl014901

Glover, P. W. J. (2018). Modeling pH-Dependent and Microstructure-Dependent Streaming Potential Coefficient and Zeta Potential of Porous Sandstones. Transport in Porous Media, 124(1), 31–56. https://doi.org/10.1007/s11242-018-1036-z

Hosseini, M., Ur Rahman Awan, F., Kumar Jha, N., Keshavarz, A., & Iglauer, S. (2023). Streaming and zeta potentials of basalt as a function of pressure, temperature, salinity, and pH. Fuel, 351(June), 128996. https://doi.org/10.1016/j.fuel.2023.128996

Ikpeka, P. M., Ugwu, J. O., Pillai, G. G., & Russell, P. (2022). Effectiveness of electrokinetic-enhanced oil recovery (EK-EOR): a systematic review. Journal of Engineering and Applied Science, 69(1), 60. https://doi.org/10.1186/s44147-022-00113-4

Jaafar, M. Z. (2013). Measurement of Streaming Potential in Reservoir Rocks (M. Z. Jaafar, Ed.; 1st ed.). Scholar’s Press.

Jaafar, M. Z., Ahmed, T., Sulaiman, W. R. W., & Ismail, A. R. (2015). Reservoir Monitoring Using Streaming Potential : Is the Thermoelectric Correction Necessary ? The SPE Reservoir Characterisation and Simulation Conference and Exhibition, 1–9.

Khaledialidusti, R., Kleppe, J., & Enayatpour, S. (2015, September). Mechanistic Modeling of Alkaline/Surfactant/Polymer Floods Based on the Geochemical Reactions for Snorre Reservoir. SPE Reservoir Characterisation and Simulation Conference and Exhibition.

Kim, M., Haroun, M., Rahman, M., & Kobaisi, M. Al. (2019). Hybrid Nano Acid Fluid Pulsed with Electro-kinetic to Stimulate Tight Carbonate Reservoirs : A Novel EOR / IOR Method. Spe/Iatmi Asia Pacific Oil & Gas Conference and Exhibition, 1–17.

Korrani, A. K. N., & Jerauld, G. R. (2018). Modeling Wettability Change in Sandstones and Carbonates Using a Surface-Complexation-Based Method. The SPE Improved Oil Recovery Conference, 2018, 1–27.

Lawson Scientific. (2010). Zeta Potential – Electrophoresis, Electroacoustics and Streaming Potential. In Engineering.

Nazarova, M., Bouriat, P., & Creux, P. (2018). Electrical double layer expansion impacts the oil-quartz adhesion for high and low salinity brines. Energy & Fuels, 30, 1–31. https://doi.org/10.1021/acs.energyfuels.7b03954

Nasution, A.M., Putra, D.F. (2022). Investigasi Sifat ION Na+ & NH4 + Pada Hybrid-Alkali ASP Flooding Menggunakan Simulator CMG GEM 2020. Lembaran Publikasi Minyak dan Gas Bumi, 56 (36), 133–145. https://doi.org/10.29017/LPMGB.56.3.1099

Park, C., Kang, J. M., Jung, Y., & Kim, S. (2006). Streamline-based simulation to investigate inter-well connectivity and tracer transport in the 3D discrete fractured reservoir. Society of Petroleum Engineers, 68th European Association of Geoscientists and Engineers Conference and Exhibition, Incorporating SPE EUROPEC 2006, EAGE 2006: Opportunities in Mature Areas, 5, 2787–2796. https://doi.org/10.2118/100216-ms

Probstein, R. F., & Hicks, R. E. (1993). Removal of contaminants from soils by electric fields. Science, 260(5107), 498–503.

Putra, D. F., Jaafar, M. Z., Husbani, A., Ma’sum, H.A., Fadhil, M. (2024). Refined Fluid Property Characterization in Data-Limited Reservoirs: Evaluating EOS and Black Oil Models for Optimized Simulation of The PSE Field in The Central Sumatra Basin. Scientific Contributions Oil and Gas. 47(3) 243-264. https://doi.org/10.29017/SCOG.47.3.1632

Putra, D. F., Jaafar, M. Z., & Hakim, I. (2024). Introduction Unconventional Monitoring of Fluid Front of ASP Flooding from Chemical Tracer to Streaming Potential Method in Sandstone: A Review. Journal of Earth Energy Engineering, 13(1), 1–14. https://doi.org/10.25299/jeee.2024.10995

Putra, D. F., Jaafar, M. Z., T. Mohd, T. Amran, Putra, M. H. T., Kocabas, I., Lukman, I. A., Hafeni, V.T (2025). Innovating EOR Strategies: Unlocking the Potential of Streaming Potential (Electro-kinetic) as Sustainable and Eco-friendly Surveillance Tools for Monitoring ASP Fluid Front. The SPE Advances in Integrated Reservoir Modelling and Field Development Exhibition & Conference, June 2–4.

Putra, D. F., Jaafar, M. Z., Khalif, K. M. N., Siswanto, A., Lukman, I, Kurniawan, A (2025). Maximizing oil recovery in sandstone reservoirs through optimized ASP injection using the super learner algorithm. Communications in Science and Technology 10(1)148–159. https://doi.org/10.21924/cst.10.1.2025.1649

Revil, A., & Mahardika, H. (2013). Coupled hydromechanical and electromagnetic disturbances in unsaturated porous materials. Water Resources Research, 49, 744–766. https://doi.org/doi:10.1002/wrcr.20092,2013

Revil, A., & Pezard, P. A. (1999). Streaming potential in porous media 1 . Theory of the zeta potential. Journal of Geophysical Research, 104(B9), 21–31.

Sadeqi-Moqadam, M., Riahi, S., & Bahramian, A. (2016). An investigation into the electrical behavior of oil/water/reservoir rock interfaces: The implication for improvement in wettability prediction. Colloids and Surfaces A: Physicochemical -and Engineering Aspects, 490, 268–282. https://doi.org/10.1016/J.COLSURFA.2015.11.040

Saputra, D. D. S. M., Prasetiyo, B. D.,, Eni, H., Taufantri, Y., Damara, G., Rendragraha, Y., D. (2022). Investigation of Polymer Flood Performance in Light Oil Reservoir: Laboratory Case Study. Scientific Contributions Oil and Gas, 47(2), 81–85. https://doi.org/10.29017/SCOG.45.2.1181

Tang, K., Li, Z., Da Wang, Y., McClure, J., Su, H., Mostaghimi, P., & Armstrong, R. T. (2023). A Pore-Scale Model for Electro-kinetic In situ Recovery of Copper: The Influence of Mineral Occurrence, Zeta Potential, and Electric Potential. Transport in Porous Media, 150(3), 601–626. https://doi.org/10.1007/s11242-023-02023-2

Thanh, L. D. (2018). Streaming Potential and Zeta Potential Measurements in Porous Rocks. Journal of Geoscience and Environment Protection, 6 (November), 89–100. https://doi.org/10.4236/gep.2018.611007

Tobing, E. M. L., Eni, H. (2014). Study in Enhance Oil Recovery with Alkaline Surfactant Polymer Method by using Laboratory Test. Scientific Contributions Oil and Gas, 37(3), 175–184. https://doi.org/10.29017/SCOG.37.3.638

Xie, Q., Liu, F., Chen, Y., Yang, H., Saeedi, A., & Hossain, M. (2019). Effect of electrical double layer and ion exchange on low salinity EOR in a pH-controlled system. Journal of Petroleum Science and Engineering, 174(October 2018), 418–424. https://doi.org/10.1016/j.petrol.2018.11.050